|
|
05-10-2014, 11:59 AM
|
#21
|
Full Time Camper
Join Date: May 2011
Location: So. Cal.
Posts: 577
|
I always touch my gas vehicles with my hands to eliminate static electricity first before touching the nozzle to the vehicle filler.
Better to be extra cautious.
__________________
Bob and Better Half
2007 F-250 PSD, SW, CC, LB, 2WD
2006 TF32SS Cross Terrain Toy Hauler (sold)
Reese 16k slider
|
|
|
05-10-2014, 01:07 PM
|
#22
|
Family Vacation Member
Join Date: Oct 2013
Location: michigan
Posts: 103
|
So. True electrical shocks and little sparks can happen easily. I also did forget about the copper to the water heater.
|
|
|
05-10-2014, 03:43 PM
|
#23
|
Full Time Camper
Join Date: Oct 2004
Location: Texas
Posts: 1,508
|
I rarely turn the frig. off while refueling. IMO there is a bigger risk at the pumps from static electricity, cell phone operation, smoking and running engines/hot exhaust than from the frig. Years ago, RV didn't have ignitors but pilot lights. First fifth wheel we owned had pilot lights for the furnace, water heater and frig. It was a pain having to light the furnace and water heater each evening. The frig. pilot light was on 100% of the time, for weeks at a time when we were on the road.
__________________
Larry Day
Texas Baptist Men-Retiree Builders member since '01
13 Silverado 3500HD D/A, 2wd CCSB srw, custom RKI bed
11 Cruiser CF32MK
https://www.picturetrail.com/dayle1
|
|
|
05-10-2014, 07:08 PM
|
#24
|
Site Team
Join Date: Dec 2007
Location: WI.
Posts: 9,160
|
Larry, I would say you are a lucky man.
|
|
|
05-11-2014, 08:03 AM
|
#25
|
Full Time Camper
Join Date: Feb 2006
Location: Texas
Posts: 527
|
For almost 30 years the fridge is always on propane when we are on the road and so far never had a problem. We followed Greg Paine's lead and made a modification to our 2005 29RK that allows you to turn off the fridge without having to go into the unit to do so. Not sure why I haven't done it to the 335SS but think that I will. The instructions are very simple and are below. You can see all of the modifications that Greg made to his 2005 CF29RK here: http://www.gregpaine.com/cr/
Paine's Pointers
# 040 Outside Fridge Switch
Time Required
I prefer not to do it but there are times when we travel with the fridge running on LPG. Some folks say they do it all the time and others say it is unsafe. Regardless, when it’s time to fuel up the fridge must be shut off prior to pulling up to the pumps then turned back on after pulling away. With our CF29RK floorplan this is a pain in the butt because you have to crawl over the countertop to get to the switch. I had thought about installing a switch outside somewhere but never got around to it. While replacing the broken lower control board I decided to install a switch and it turned out to be a simple job. I’ve used it once and it was great. Just pull over, run back, flip the switch and you’re ready to go.
NAPA was in the neighborhood so I bought the switch there. I also bought a weatherproof boot to help protect the switch from the elements. My pictures don’t show it but there is a 4 post terminal block for the 12VDC connections; a pos and neg from the battery and a pos and neg going to the fridge. I disconnected the pos going to the fridge and connected it to the switch; I added a wire from the terminal block to the switch.
Parts List:
- NAPA switch – part # TG6260
- NAPA switch boot – TG6571
- 18” of 14 gauge wire
I didn’t want to install the switch in the cover because it would be a problem to remove the cover; I’d either have to disconnect the wires each time or use wires long enough to allow the cover to sit on the bumper; neither ideal. I mounted the switch in this corner so the factory wire would reach without extending it. The switch fit perfectly into the corner; close enough to the latch for support, far enough away from the latch to not interfere.
The tip of the switch sticks out thru the hole in the cover.
__________________
George & Lynda
College Station, TX
2011 Cruiser CF335SS Patriot
'04 Dodge 2500 Quadcab CTD
|
|
|
05-11-2014, 08:48 AM
|
#26
|
Full Time Camper
Join Date: Oct 2004
Location: Texas
Posts: 1,508
|
Quote:
Originally Posted by Lloyd
Larry, I would say you are a lucky man.
|
Lloyd, Not really, traveling in very hot weather or long distances, like I do, it is just trading one risk against another risk. And with those old refers w/o ignitors, it was a major pain to restart them. Pull the outside vent cover, turn the gas valve to 'pilot', strike a match while pushing the valve, then turn the gas valve to 'on', finally reinstalling the outside vent. High winds or rain just added to the problem.
Now days, the diesel vehicle next to you will have a hot exhaust pipe much closer to any gas fumes and fully able to ignite them.
__________________
Larry Day
Texas Baptist Men-Retiree Builders member since '01
13 Silverado 3500HD D/A, 2wd CCSB srw, custom RKI bed
11 Cruiser CF32MK
https://www.picturetrail.com/dayle1
|
|
|
05-12-2014, 02:14 PM
|
#27
|
Full Time Camper
Join Date: Mar 2013
Location: United states of america
Posts: 1,570
|
Quote:
Originally Posted by gball
For almost 30 years the fridge is always on propane when we are on the road and so far never had a problem. We followed Greg Paine's lead and made a modification to our 2005 29RK that allows you to turn off the fridge without having to go into the unit to do so. Not sure why I haven't done it to the 335SS but think that I will. The instructions are very simple and are below. You can see all of the modifications that Greg made to his 2005 CF29RK here: http://www.gregpaine.com/cr/
Paine's Pointers
# 040 Outside Fridge Switch
Time Required
I prefer not to do it but there are times when we travel with the fridge running on LPG. Some folks say they do it all the time and others say it is unsafe. Regardless, when it’s time to fuel up the fridge must be shut off prior to pulling up to the pumps then turned back on after pulling away. With our CF29RK floorplan this is a pain in the butt because you have to crawl over the countertop to get to the switch. I had thought about installing a switch outside somewhere but never got around to it. While replacing the broken lower control board I decided to install a switch and it turned out to be a simple job. I’ve used it once and it was great. Just pull over, run back, flip the switch and you’re ready to go.
NAPA was in the neighborhood so I bought the switch there. I also bought a weatherproof boot to help protect the switch from the elements. My pictures don’t show it but there is a 4 post terminal block for the 12VDC connections; a pos and neg from the battery and a pos and neg going to the fridge. I disconnected the pos going to the fridge and connected it to the switch; I added a wire from the terminal block to the switch.
Parts List:
- NAPA switch – part # TG6260
- NAPA switch boot – TG6571
- 18” of 14 gauge wire
I didn’t want to install the switch in the cover because it would be a problem to remove the cover; I’d either have to disconnect the wires each time or use wires long enough to allow the cover to sit on the bumper; neither ideal. I mounted the switch in this corner so the factory wire would reach without extending it. The switch fit perfectly into the corner; close enough to the latch for support, far enough away from the latch to not interfere.
The tip of the switch sticks out thru the hole in the cover.
|
This is a good idea. Kudos
Can I use a 12v lighted waterproof rocker switch? I'd like the idea of a lighted rocker, just not sure the line to the fridge is 12v or 110v.
__________________
2017 Ford F350 Super Duty 6.7 King Ranch Crew
Sold the 2016 Crossroads Sunset Trail Grand Reserve 32BH
2020 Grand Design Momentum 320G
|
|
|
05-12-2014, 02:21 PM
|
#28
|
Site Team
Join Date: Dec 2007
Location: WI.
Posts: 9,160
|
Quote:
Originally Posted by OhioMark
This is a good idea. Kudos
Can I use a 12v lighted waterproof rocker switch? I'd like the idea of a lighted rocker, just not sure the line to the fridge is 12v or 110v.
|
George knows!!
|
|
|
05-12-2014, 04:05 PM
|
#29
|
Full Time Camper
Join Date: Feb 2006
Location: Texas
Posts: 527
|
I think that any type of 12 volt switch would work. Just a matter of preference as to which one you would want to use.
__________________
George & Lynda
College Station, TX
2011 Cruiser CF335SS Patriot
'04 Dodge 2500 Quadcab CTD
|
|
|
05-13-2014, 08:57 AM
|
#30
|
Full Time Camper
Join Date: Mar 2013
Location: United states of america
Posts: 1,570
|
Quote:
Originally Posted by gball
I think that any type of 12 volt switch would work. Just a matter of preference as to which one you would want to use.
|
Thanks,
I can't tell from the photo...can you throw the switch without removing the cover?
__________________
2017 Ford F350 Super Duty 6.7 King Ranch Crew
Sold the 2016 Crossroads Sunset Trail Grand Reserve 32BH
2020 Grand Design Momentum 320G
|
|
|
05-13-2014, 09:14 AM
|
#31
|
Full Time Camper
Join Date: Aug 2012
Location: Belle River , Ontario
Posts: 1,753
|
I'm assuming yes . why else would it be sticking out. hhmmm
I have also seen one with the switch just inside ,and one of the little vent pieces cut out to get your finger in to shut off and turn on with out taking cover off.
__________________
It was a rainy few days at Algonquin Prov park...tarps kept us dry.
Wayne --Belle River (Windsor), Ontario
2013 Sunset Trail Reserve 25RB..(just sold it)
2015 White Chev Silverado 2500HD 4x4 (6.0 l gasser)
2003 Mountain Star 890SBRX Truck Camper
|
|
|
05-13-2014, 10:35 AM
|
#32
|
Full Time Camper
Join Date: May 2011
Location: So. Cal.
Posts: 577
|
Boy this has become a hot topic here. I decided to Google any info I could find on rv fire statistics.
There's between 3,000 and 4,000 rv insurance claims per year but I could not find a single incident where a fire was created specifically due to traveling with a refrig connected to propane.
I'm sure there must some but after 30 minutes of searching. Not a thing.
There are incidents of refrig fires because of old line leaks, rodents and wires, Diesel engine fires under the hood, etc, but nothing tied to driving with the refrig on?
Not to say I'm advocating driving with it on or off, but I'd expect to see some statistics to validated the problem. Nothing!
I'm not sure it's truly as big of an issue as thought to be.
__________________
Bob and Better Half
2007 F-250 PSD, SW, CC, LB, 2WD
2006 TF32SS Cross Terrain Toy Hauler (sold)
Reese 16k slider
|
|
|
05-13-2014, 10:58 AM
|
#33
|
Full Time Camper
Join Date: Mar 2013
Location: United states of america
Posts: 1,570
|
Bob,
Your probably right. I'm risk adverse. 10 bucks in parts and half hour of my time, hey why tempt fate, right?
__________________
2017 Ford F350 Super Duty 6.7 King Ranch Crew
Sold the 2016 Crossroads Sunset Trail Grand Reserve 32BH
2020 Grand Design Momentum 320G
|
|
|
05-13-2014, 12:54 PM
|
#34
|
Weekend Camper
Join Date: Feb 2014
Location: ILLINOIS
Posts: 66
|
If you're going to put a switch out there I'd think about two things - security around someone turning it on/off without me knowing. Also maybe make the switch so there is some type of indicator if it's on - led etc?
__________________
2014 RAM 2500 Laramie MegaCab Diesel towing our 2014 Sunset Trails 320BH
|
|
|
05-13-2014, 01:11 PM
|
#35
|
Full Time Camper
Join Date: Feb 2006
Location: Texas
Posts: 527
|
The switch that Greg installed is a simple toggle switch and it is operated without taking the vent cover off. Very easy to tell if it is off or on by the location of the lever. I never had anyone bother the unit on the 29RK. Doesn't mean that someone wouldn't, but unless they knew what it was for why would they? Since it is visible a quick check would assure that it was on.
__________________
George & Lynda
College Station, TX
2011 Cruiser CF335SS Patriot
'04 Dodge 2500 Quadcab CTD
|
|
|
05-13-2014, 02:12 PM
|
#36
|
Full Time Camper
Join Date: May 2013
Location: So IL
Posts: 1,811
|
Not advocating either, but am guilty of doing it. However, I was checking my tanks earlier and noticed right on the front cap is a sticker that says gas should be turned off during refueling. Also noticed that connecter to full tank was broke. Without the safety valve that would have let that entire tank empty. It did not and tank was still full. Took it off and went to dealer and got a replacement.
__________________
Tim
13 ST25RB
08 F-250 SC 6.8L XLT 4x4
|
|
|
05-20-2016, 04:18 AM
|
#37
|
New Camper
Join Date: May 2016
Location: Ny
Posts: 5
|
I would agree with Dayle1
|
|
|
|
|
Thread Tools |
Search this Thread |
|
|
Display Modes |
Linear Mode
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|